Operation CHARM: Car repair manuals for everyone.

Engine Coolant Temperature Sensor on Radiator, Checking






Diagnostic Procedures


Engine Coolant Temperature Sensor on Radiator, Checking

Special tools, testers and auxiliary items required

• Multimeter (VAG1526) or multimeter (VAG1715)

• Connector test kit (VAG1594)

• Wiring diagram

Test requirements

Fuses in E-box (in plenum chamber, left) must be OK:





Ground (GND) connections between engine and chassis must be OK.

Ignition switched off.

Test sequence

- Disconnect 2-pin connector from Engine Coolant Temperature (ECT) Sensor (on Radiator) (G83) (arrow).





Checking resistance

- Measure resistance at Engine Coolant Temperature (ECT) Sensor (on Radiator) (G83).





Range A displays resistance values for the temperature range of 0 to 50° C, range B displays resistance values for the temperature range of 50 to 100° C.





Read-out examples:

• 30° C is in range A and corresponds to a resistance of 1.5 to 2.0 kohms

• 80° C is in range B and corresponds to a resistance of 275 to 375 ohms

If specified value is not obtained:

- Replace Engine Coolant Temperature (ECT) Sensor (on Radiator) (G83).

CAUTION!
• The cooling system is under pressure.

• Danger of scalding when opening!

- Erase DTC memory of Engine Control Module (ECM) , Diagnostic mode 4: Reset/erase diagnostic data.

- Generate readiness code.

If specified value is obtained:

- Check wires according to wiring diagram.

Checking wiring

- Connect test box to control module wiring harness , connect test box for wiring test.

- Check wires between test box and 2-pin connector for open circuit according to wiring diagram.





Terminal 1+socket 17

Terminal 2+socket 50

Wire resistance: max. 1.5 ohms

- Also check wires for short circuit to each other, to vehicle Ground (GND) and to B+.

Specified value: infinite ohms

- Erase DTC memory of Engine Control Module (ECM) , Diagnostic mode 4: Reset/erase diagnostic data.

- Generate readiness code.

If no malfunctions are detected in the wires and the resistance values are OK:

- Replace Motronic Engine Control Module (ECM) (J220).